DBDS10P1A/200力士樂溢流閥現貨庫存

DBDS10P1A/200力士樂溢流閥現貨庫存

武漢百士自動化設備有限公司專注于液壓、氣動、工控自動化備件銷售，熱誠歡迎新老客戶咨詢購買！

溢流閥是一種液壓壓力控制閥，在液壓設備中主要起定壓溢流作用，穩壓，系統卸荷和安全保護作用。
定壓溢流作用：在定量泵節流調節系統中，定量泵提供的是恒定流量。當系統壓力增大時，會使流量需求減小。此時溢流閥開啟，使多余流量溢回油箱，*證溢流閥進口壓力，即泵出口壓力恒定（閥口常隨壓力波動開啟）。
穩壓作用：溢流閥串聯在回油路上，溢流閥產生背壓，運動部件平穩性增加。
系統卸荷作用：在溢流閥的遙控口串接溢小流量的電磁閥，當電磁鐵通電時，溢流閥的遙控口通油箱，此時液壓泵卸荷。溢流閥此時作為卸荷閥使用。
安全保護作用：系統正常工作時，閥門關閉。只有負載超過規定的極限（系統壓力超過調定壓力）時開啟溢流，進行過載保護，使系統壓力不再增加（通常使溢流閥的調定壓力比系統高工作壓力高10%～20%）。
實際應用中一般有：作卸荷閥用，作遠程調壓閥，作高低壓多*控制閥，作順序閥，用于產生背壓（串在回油路上）。
溢流閥一般有兩種結構：1、直動型溢流閥 。2、先導式溢流閥。
對溢流閥的主要要求：調壓范圍大，調壓偏差小，壓力振擺小，動作靈敏，過載能力大，噪聲小。
2注意事項
噪聲和振動
液壓裝置中容易產生噪聲的元件一般認為是泵和閥，閥中又以溢流閥和電磁換向閥等為主。產生噪聲的因素很多。溢流閥的噪聲有流速聲和機械聲二種。流速聲中主要由油液振動、空穴以及液壓沖擊等原因產生的噪聲。機械聲中主要由閥中零件的撞擊和磨擦等原因產生的噪聲。
（1）壓力不均勻引起的噪聲
先導型溢流閥的導閥部分是一個易振部位如圖3所示。在高壓情況下溢流時，導閥的軸向開口很小，僅0.003～0.006厘米。過流面積很小，流速很高，可達200米/秒，易引起壓力分布不均勻，使錐閥徑向力不平衡而產生振動。另外錐閥和錐閥座加工時產生的橢圓度、導閥口的臟物粘住及調壓彈簧變形等，也會引起錐閥的振動。所以一般認為導閥是發生噪聲的振源部位。
由于有彈性元件（彈簧）和運動質量（錐閥）的存在，構成了一個產生振蕩的條件，而導閥前腔又起了一個共振腔的作用，所以錐閥發生振動后易引起整個閥的共振而發出噪聲，發生噪聲時一般多伴隨有劇烈的壓力跳動。
（2）空穴產生的噪聲
當由于各種原因，空氣被吸入油液中，或者在油液壓力低于大氣壓時，溶解在油液中的部分空氣就會析出形成氣泡，這些氣泡在低壓區時體積較大，當隨油液流到高壓區時，受到壓縮，體積突然變小或氣泡消失；反之，如在高壓區時體積本來較小，而當流到低壓區時，體積突然增大，油中氣泡體積這種急速改變的現象。氣泡體積的突然改變會產生噪聲，又由于這一過程發生在瞬間，將引起局部液壓沖擊而產生振動。先導式溢流閥的導閥口和主閥口，油液流速和壓力的變化很大，很容易出現空穴現象，由此而產生噪聲和振動。
（3）液壓沖擊產生的噪聲
先導式溢流閥在卸荷時，會因液壓回路的壓力急驟下降而發生壓力沖擊噪聲。愈是高壓大容量的工作條件，這種沖擊噪聲愈大，這是由于溢流閥的卸荷時間很短而產生液壓沖擊所致在卸荷時，由于油流速急劇變化，引起壓力突變，造成壓力波的沖擊。壓力波是一個小的沖擊波，本身產生的噪聲很小，但隨油液傳到系統中，如果同任何一個機械零件發生共振，就可能加大振動和增強噪聲。所以在發生液壓沖擊噪聲時，一般多伴有系統振 動。

R900443564 DBDS10P1X/630B
R901010836 DBDS10P1X/630E
R900940968 DBDS10P1X/630P600
R900446684 DBDS10P1X/630V
R900777835 DBDS10P1X/630VE
R900523060 DBDS10P1X/700
R900572366 DBDS10P1X/70B
R901043646 DBDS10P1X/70E
R900900576 DBDS10P1X/70VB
R901259368 DBDS10P1X/70VE
R900572367 DBDS10P1X/75B
R901249057 DBDS10P1X/75E
R900572368 DBDS10P1X/80B
R901053481 DBDS10P1X/80E
R900572369 DBDS10P1X/90B
R900781736 DBDS10P1X/90E
R900424162 DBDS15G1X/100
R901100464 DBDS15G1X/100-80
R900369921 DBDS15G1X/100/12
R900471345 DBDS15G1X/100/5
R900473963 DBDS15G1X/100/V/5
R900572370 DBDS15G1X/100B
R900487914 DBDS15G1X/100J
R900437650 DBDS15G1X/100V
R900423813 DBDS15G1X/110B
R900572473 DBDS15G1X/120B
R900572474 DBDS15G1X/125B
R900936981 DBDS15G1X/130B
R900572475 DBDS15G1X/140B
R900572476 DBDS15G1X/150B
R900572477 DBDS15G1X/155B
R900940165 DBDS15G1X/160B
R900427607 DBDS15G1X/170B
R901029734 DBDS15G1X/170E
R900392610 DBDS15G1X/170VB
R900424163 DBDS15G1X/200
R900346748 DBDS15G1X/200W40
R901218596 DBDS15G1X/200-100JV
R900375503 DBDS15G1X/200/12
R900466655 DBDS15G1X/200/2
R900473976 DBDS15G1X/200/5
R900414787 DBDS15G1X/200/V/5
R900572563 DBDS15G1X/200B
R901006620 DBDS15G1X/200E
R900383338 DBDS15G1X/200J
R901053727 DBDS15G1X/200J=TE
R900522370 DBDS15G1X/200JV
R900560482 DBDS15G1X/200MT
R900958596 DBDS15G1X/200P120
R901407545 DBDS15G1X/200P140
R901198707 DBDS15G1X/200P145
R901121891 DBDS15G1X/200P150
R901411898 DBDS15G1X/200P155
R901411897 DBDS15G1X/200P160
R900424164 DBDS15G1X/200V
R900425171 DBDS15G1X/210B
R900426898 DBDS15G1X/25
R900433410 DBDS15G1X/25SO74
R900456750 DBDS15G1X/25W1
R900348892 DBDS15G1X/25W28
R900376483 DBDS15G1X/25W40
R900968630 DBDS15G1X/25-10
R901381327 DBDS15G1X/25-5
R900350325 DBDS15G1X/25/12
R900474537 DBDS15G1X/25/5
R900474537 DBDS15G1X/25/5
R900965058 DBDS15G1X/250B
R900774363 DBDS15G1X/250E
R901204808 DBDS15G1X/25J
R901052300 DBDS15G1X/25J=TE
R900701673 DBDS15G1X/25P10
R900909850 DBDS15G1X/25P15
R901361763 DBDS15G1X/25P25
R900470269 DBDS15G1X/25V
R901055988 DBDS15G1X/300E
R900424165 DBDS15G1X/315
R900915894 DBDS15G1X/315-210
R900458682 DBDS15G1X/315/12
R900471705 DBDS15G1X/315/5
R900474800 DBDS15G1X/315/V/5
R900432155 DBDS15G1X/315B
R901005297 DBDS15G1X/315E
R900487915 DBDS15G1X/315J
R901052256 DBDS15G1X/315J=TE
R900380104 DBDS15G1X/315MT
R901232017 DBDS15G1X/315P230
R900474169 DBDS15G1X/315V
R900347258 DBDS15G1X/315V/12
R900952224 DBDS15G1X/315VB
R900572932 DBDS15G1X/350B
R900424166 DBDS15G1X/400
R901375299 DBDS15G1X/400-330V
R901324387 DBDS15G1X/400-370
R900749008 DBDS15G1X/400-380
R900353041 DBDS15G1X/400/12
R900473978 DBDS15G1X/400/5
R900378667 DBDS15G1X/400/V/5
R900449819 DBDS15G1X/400B
R901052259 DBDS15G1X/400J=TE
R901037475 DBDS15G1X/400V
R900424167 DBDS15G1X/50
R900534613 DBDS15G1X/50/12
R900372063 DBDS15G1X/50/5
R900338486 DBDS15G1X/50/V/5
R900572303 DBDS15G1X/50B
R900389786 DBDS15G1X/50J
R901410144 DBDS15G1X/50P40
R900433981 DBDS15G1X/50V
R900781549 DBDS15G1X/55E
R900464653 DBDS15G1X/60B
R900977225 DBDS15G1X/70B
R900572371 DBDS15G1X/80B
R900440468 DBDS15P1X/100
R900429784 DBDS15P1X/200
R900450103 DBDS15P1X/25
R900424169 DBDS15P1X/315
R900432157 DBDS15P1X/50
R900347864 DBDS2K1X/100
R900493208 DBDS2K1X/100J
R900347903 DBDS2K1X/100V
R900347871 DBDS2K1X/200
R900347902 DBDS2K1X/200V
R900387390 DBDS2K1X/25
R900387777 DBDS2K1X/25V
R900356421 DBDS2K1X/315
R900388233 DBDS2K1X/315SO150
R900201825 DBDS2K1X/315-230
R900201825 DBDS2K1X/315-230
R900493210 DBDS2K1X/315J
R900353186 DBDS2K1X/315V
R900354632 DBDS2K1X/420
R900377054 DBDS2K1X/420SO150
R900382899 DBDS2K1X/420SO270
R900051028 DBDS2K1X/420-320
R900518220 DBDS2K1X/420MK
R900205449 DBDS2K1X/420P420
R900361555 DBDS2K1X/420V
R900345197 DBDS2K1X/50
R900446910 DBDS2K1X/50SO115
R900347901 DBDS2K1X/50V
R900424170 DBDS20G1X/100
R900478643 DBDS20G1X/100SO130
R900925324 DBDS20G1X/100-055
R900974735 DBDS20G1X/100-075
R900346720 DBDS20G1X/100/12
R900535542 DBDS20G1X/100/2
R900471600 DBDS20G1X/100/5
R900470507 DBDS20G1X/100/5
R900413535 DBDS20G1X/100/V/5
R900572372 DBDS20G1X/100B
R901014525 DBDS20G1X/100E
R900592246 DBDS20G1X/100J
R901053364 DBDS20G1X/100J=TE
R900382224 DBDS20G1X/100MT
R900424171 DBDS20G1X/100V
R900534735 DBDS20G1X/100V/12
R900921194 DBDS20G1X/100VB
R900428381 DBDS20G1X/110B
R901033180 DBDS20G1X/110E
R900572478 DBDS20G1X/120B
R900769577 DBDS20G1X/120E
R900572479 DBDS20G1X/130B
R901109433 DBDS20G1X/130VE
R900572480 DBDS20G1X/140B
R901002446 DBDS20G1X/140E
R900947647 DBDS20G1X/140VB
R900572481 DBDS20G1X/150B
R901017079 DBDS20G1X/150E

產品報價及貨期說明 因工業液壓、自動化各*牌備件型號繁多，歐美產品價格貨期實時變化，因此很難實時標出準確價格，故具體產品信息、報價及貨期請以我公司報價單為準 ,給您帶來不便敬請諒解！以上信息由武漢百士公布，解釋權歸武漢百士自動化設備有限公司所有。感謝您的合作，竭誠為您服務。